Product ID:D-5010 CORROSION PREVENTIVE, 66 1002
MSDS Date:11/30/1989
FSC:6850
NIIN:00N012996
MSDS Number: BKJZY

ANDPACK-EMA INC.

1860 DOBBIN DRIVE
SAN JOSE, CA 95133
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 408-729-0291

Preparer: DEAN DARWIN

Cage: HO784

ANDPAK-EMA INC DBA ZIPCHEM PRODUCTS

SAN JOSE, CA 95133 US

Telephone: 408-272-8007

Cage: 0GR20

MINERAL SPIRITS

CAS: 64742-47-8

Fraction By Weight: 30%

OSHA PEL N/K

ACGIH TLV: N/K

LIGHT MINERAL OIL MIXTURE

Fraction By Weight: 10%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

TRICHLOROFLUOROMETHANE (CFC-11) (SARA III)

CAS: 75-69-4

RTECS: PB6125000

Fraction By Weight: 25%

OSHA PEL 1000 PPM

ACGIH TLV: C, 1000 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DICHLORODIFLUOROMETHANE (SARA III)

CAS: 75-71-8

RTECS: PA8200000

Fraction By Weight: 27%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN BE EXPECTED TO BE AN EYE
IRRITANT. SKIN: LIQUID CONTACT MAY CAUSE FROSTBITE & OR DEFATTING
OF SKIN. NOT A CORROSIVE IRRITANT, MAY CAUSE MINOR SKIN IRRITATION.
INHAL: MAY CAUSE DIZZINESS, HEA DACHE, OR NAUSEA. THIS MAY LEAD TO
NARCOSIS, CARDIAC IRREGULARITIES, UNCON OR DEATH. INGEST: NOT
LIKELY TO BE (SUPP)
Effects of Overexposure:(SEE HEALTH HAZARDS)
Medical Cond Aggravated by Exposure:BECAUSE OF POSSIBLE INCREASED RISK
OF ELICITING CARDIAC DYSRYTHMIAS, EPINEPHRINE SHOULD BE GIVEN AS
LAST RESORT.

First Aid:EYES: IMMED FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15
MIN. CALL MD. SKIN: WASH SKIN THOROUGHLY WITH SOAP AND WATER. TREAT
FOR FROSTBITE IF NECESSARY. OBTAIN MEDICAL ATTENTION IF IRRIT
PERSISTS. INHAL: REMOVE TO FRESH AIR, CALL MD. IFNOT BREATHING
GIVE MOUTH TO MOUTH. IF BREATHING DIFFICULT GIVE OXYGEN. INGEST:
GIVE MILK OR WATER. DO NOT INDUCE VOMITING. ASPIR OF MATL IS A
GREATER DANGER.

Flash Point Method:TCC
Flash Point:>105F,>41C
Autoignition Temp:Autoignition Temp Text:N/K FN
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE STANDARD FIREFIGHTING PROCEDURES TO
EXTINGUISH FIRES INVOLVING PETROLEUM PRODUCTS.
Unusual Fire/Explosion Hazard:AEROSOL CONTAINERS MAY EXPLODE IF
SUBJECTED TO HEAT OR FLAME ABOVE 130F. DECOMPOSITION MAY OCCUR.

Spill Release Procedures:VENTILATE AREA. DO NOT FLUSH INTO SEWERS.
COLLECT ON AN ABSORBENT MATERIAL AND TRANSFER INTO STEEL DRUMS OR
RECOVERY DRUM.
Neutralizing Agent:N/K

Handling and Storage Precautions:DO NOT STORE ABOVE 120 DEG F. DO NOT
PUNCTURE OR INCINERATE. KEEP AWAY FROM OPEN FLAMES.
Other Precautions:CONTAINS PETROLEUM DISTILLATES, IF SWALLOWED DO NOT
INDUCE VOMITING. CALL MD. DO NOT GIVE CATECHOLAMINE DRUGS SUCH AS
EPINEPHRINE. KEEP OUT OF REACH OF CHILDREN. AVOID PROLONGED OR
REPEATED BREATHING OF VAPOR. DO NOT TAKE INTERNALLY.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR EXPOSURE OF
CONCERN .
Ventilation:VENTILATION APPROPRIATE FOR CONDITIONS OF USE.CONSULT
INDUSTRIAL HYGIENIST/SAFETY SPECIALIST FOR SPECIFIC GUIDANCE
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEM WORKER GOGG.MAY ADD (SEE SUPP DATA)
Work Hygienic Practices:USE IN WELL VENTILATED AREAS. USE GOOD HYGIENIC
PRACTICES WHEN DEALING WITH THIS PRODUCT.
Supplemental Safety and Health
HLTH HAZ: FATAL IF INGESTED. DO NOT INDUCE VOMITING. CAN BE HARMFUL IF
ASPIRATED INTO LUNGS. EYE PROT: FULL LENGTH FACE SHIELD TO GOGGLES
.

HCC:V3
Boiling Pt:B.P. Text:-22F,-30C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:> AIR
Spec Gravity:1.1
Viscosity:N/K
Evaporation Rate & Reference:FASTER THAN ETHER.
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:AMBER LIQUID WITH SLIGHT ETHEREAL ODOR.
Corrosion Rate:

Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS-POWDERED AL, ZN, AND STRONG OXIDIZING
MATERIALS.
Stability Condition to Avoid:OPEN FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:HALOGENATED ACIDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:COLLECT ON ABSORBENT MATERIAL AND TRANSFER TO
STEEL DRUMS OR RECOVERY DRUMS FOR DISPOSAL IN ACCORDANCE WITH ALL
FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.